Effect of Curing Age on Chloride Diffusion Coefficient of Recycled Aggregate Concrete Subjected to Compressive Stresses

， ， ， ，

College of Aerospace Engineering，Nanjing University of Aeronautics and Astronautics，Nanjing 210016，P．R．China

0 Introduction

As one of the pillar industries of the national economy，the construction industry has developed rapidly in recent years，but the construction waste has also increased sharply．Within all of the construction waste，the amount of waste concrete is the largest，which accounts for about 30%—50%by weight［1］．On the other hand，the sources of suitable natural aggregate have been diminished severely．Therefore，the use of recycle aggregate（RA）in the production of new concrete has become increasingly popular and costeffective［2］．

However，compared with natural aggregate（NA），a lot of micro cracks and fissures produced in the process of waste concrete disintegration and fragmentation，as well as old cement mortar that remains attaching to the virgin aggregate of RA，make RA have a higher porosity and more large pores，thus leading to the durability of recycled aggregate concrete（RAC）lower than that of natural aggregate concrete（NAC）．Since chloride－induced corrosion is the most prominent cause for the deterioration of reinforced concrete，the durability of concrete is closely related to chloride penetration．The chloride diffusion coefficient has been widely considered as the most important index for evaluating the durability of recycled aggregate concrete．

The micro cracks and pores in concrete significantly influence the chloride diffusion coefficient，and the curing age can affect the resistance to chloride penetration of concrete by changing micro cracks and pores．As the curing age increases，the micro cracks and pores in the concrete decrease and the resistance to chloride penetration improves．Therefore，the influence of curing age on chloride diffusion coefficient should be investigated．Nowadays，the researches on the change trend of the resistance to chloride ion permeability of natural aggregate concrete with curing age have been widely conducted and lots of research results have been obtained［3－5］．But the large porosity and the high water absorption of recycled aggregate may deviate the chloride diffusion coefficient of recycled aggregate concrete from that of natural aggregate concrete．To date，the researches on the chloride diffusion coefficient of recycled aggregate concrete have been reported．Limbachiya et al．［6］found that the chloride diffusion coefficient decreased with the increase of the replacement ratio of recycled coarse aggregate．While Zhang et al．［7］observed that the chloride diffusion coefficient of recycled concrete firstly decreased and then increased with the increase of the replacement ratio of recycled coarse aggregate．The results of Ye et al．［8］showed that the decrease of water cement ratio could improve the resistance to chloride ion penetration of recycled concrete．Moreover，the chloride penetration of recycled concrete is done under external loads in practical engineering，so it is significant to study the chloride diffusion coefficient of recycled concrete subjected to external loads．Wang et al．［9］found that the chloride diffusion coefficient of recycled aggregate concrete presents a trend of firstly decreasing and then increasing as the compressive load increases．But the aforementioned research focuses on the influences of the replacement ratio of recycled aggregate，water－cement ratio and compressive load，less information on the relationship between chloride diffusion coefficient of RAC and curing age is available．

In addition，when compressive load is applied to recycled aggregate concrete，the micro cracks and pores may close up and expand，even generating new cracks．Consequently，the chloride diffusion coefficient will change，as well as the change trend of the chloride diffusion coefficient with the curing age．Therefore，the influence of the compressive load should not be neglected．

The objective of this study is to investigate the effect of curing ages on chloride diffusion coefficients of recycled aggregate concrete under different compressive stress levels and to propose the relationship models．

1 Experiment

1．1 Experimental materials

The cement used for the mixes was 42．5R Portland cement supplied by China Nanjing Jiangnan Cement Plant．The fine aggregate（FA）was natural river sand with the fineness modulus of 2．6and the water content of 3%．The recycled or natural coarse aggregates were used as the coarse aggregate （CA）in the mixtures．The natural coarse aggregate（NCA）was graded gravel with a maximum particle size of 31．5mm．The recycled coarse aggregate（RCA）with the water absorption of 5．7%and the crushing index of 10．4%，which conform to the requirements of GradeⅡRA in Chinese National Standard GB／T 25177—2010［10］．The properties of NCA and RCA are shown in Table 1．Based on the design method of mix proportion of NAC，supplementary water needs to be added into the RAC in accordance with water absorption of RCA．The mix proportions and compressive strength of NAC and RAC are shown in Table 2．

Table 1 Properties of coarse aggregate

Table 2 Mix proportions and compressive strength of NAC and RAC

1．2 Concrete casting and curing

Two kinds of concrete specimens were cast here，i．e．150mm×150mm×150mm cubes and 100mm×100mm×400mm prisms．The cubic specimens were used to measure the compressive strength of concrete at 28d．The prism specimens were cut into 100mm×100mm×50mm to test the chloride diffusion coefficients of concrete under different compressive stress ratios by RCM method．After casting，the concrete specimens were cured in the water until the age of 14，28，56，90，135，180，270d，respectively．

1．3 Loading test

The setup for loading test is shown in Fig．1．The skeleton of the compressive loading setup was made up of two stainless steel bars and three stainless steel plates．In order to ensure enough strength and rigidity of the setup，all parts were made of Q345high strength stainless steel．The concrete specimens were fixed to the skeleton by a kind of special glue and compressive load was applied by two top nuts．The properties of the special glue are shown in Table 3．Furthermore the applied loadings can be controlled and checked by measuring the displacements of the disc springs during the test．By using this setup，three specimens of 100mm×100mm×50mm can be applied the same loading at the same time，which can shorten the test period and save the test cost．

As shown in Tables 4，5，after the specimens were cured for 14，28，56，90，135，180 and 270d，respectively，they were subjected to different compressive stress ratios of 0，0．3，0．6 and 0．8．Concrete compressive stress ratioλwas calculated according to the following equation

Fig．1 Setup for loading test［11］

where is the compressive strength of 100mm×100mm×50mm specimen andσthe applied stress value．

Table 3 Properties of special glue

Table 4 Stress in NAC specimens subjected to sustained compressive loadings MPa

Table 5 Stress in RAC specimens subjected to sustained compressive loadings MPa

1．4 Concrete chloride diffusion coefficient test

Here，the chloride diffusion coefficient of concrete was tested by RCM method．The test process of RCM method was performed according to NT Build 492［12］．The test method was selected because of its convenience and reliability［13］．Since the chloride diffusion coefficient of concrete subjected to sustained load was measured，the migration test setup was modified，as shown in Fig．2．Before the chloride diffusion coefficient test，the specimens under compressive stresses must be immersed in an ultrasonic bath to make the specimens be in a water－saturated state．And to ensure the chloride ion penetration into concrete in one direction，the sides of specimens should be sealed with the special glue mentioned above．Subsequently，the rubber tube was fixed on concrete surface by the special glue，the positive electrode was placed in the rubber tube and the negative electrode was fixed on concrete bottom．And anodic and cathode electrolytic solution were added in the rubber tube and the plastic pot，respectively．

Fig．2 Modified setup for migration test［9］

After the specimens were fixed in the modified setup for migration test，electro－migration test was conducted．After the migration test，the specimens axially splitted and 0．1mol／L silver nitrate solution was sprayed on the split surface immediately．After about 15min，the chloride ion diffusion penetration depth was measured according to Fig．3and chloride diffusion coefficient was calculated from the following calculation formula proposed by NT Build 492［12］

whereDRCM，0is the chloride diffusion coefficient of concrete（m2／s），Tthe average anodic electrolytic solution temperature （℃），hthe average specimen thickness（mm），Xdthe average chloride penetration depth（mm），andαan auxiliary variable．

Fig．3 Concrete chloride diffusion penetration depth test

2 Analysis and Discussion

2．1 Effect of curing age with no stresses

For natural aggregate concrete，Mangat et al．［4］and Zhou et al．［14］have given the relationship between the chloride diffusion coefficient and cu－ring age．In this study，the relationship betweenD／D0andt／t0in recycled aggregate concrete was explored，andDwas the chloride diffusion coefficient（m2／s），D0the chloride diffusion coefficient at the reference period （m2／s），andt0the reference period（t0refers to 28d）．In Fig．4，the experimental results from other researches［15－20］were compared with that of this paper．

Fig．4 Curing age vs chloride diffusion coefficient of recycled aggregate concrete and natural aggregate concrete under no stresses

In Fig．4，recycled and natural aggregate concretes with the same water－binder have the similar experimental results，i．e．，for both RAC and NAC，the chloride diffusion coefficient decreases with the increase of curing age．It was widely accepted that the setting and hardening of recycled aggregate concrete are the result of the chemical and physical reaction between cement and water［21］．At the beginning of hydration，many large capillary pores exist in the recycled aggregate concrete and total pore volume is large．As the curing time increases，the fine degree of the capillary system increases，and the amount of gel，pore volume and through－pore structure decrease．Therefore，chloride diffusion coefficient decreases with the help of deepening the degree of hydration．In addition，for both NAC and RAC，the chloride diffusion coefficient decreases quickly at the beginning and then slows down obviously with the increase of curing age．It can be implied that the chemical and physical reactions mostly occur in the earlier stage of curing and seldom occur during the later ages，which leads the resistance to chloride ion penetration to improve initially significantly but then a little．This is consistent with the conclusion of Wang et al．［22］on the change trend of NAC chloride diffusion coefficient with age．

It should be noted that before the age of 28 d （D／D0＜1），the chloride diffusion coefficients of recycled concrete are larger than those of natural concrete．Nevertheless，during the period of 28to 90d（1＜D／D0＜3．21），the chloride diffusion coefficients of recycled concrete are lower than those of natural concrete，indicating that before 90d，the chloride diffusion coefficient of recycled aggregate concrete decreases larger when compared with that of natural aggregate concrete．The larger decrease in chloride diffusion coefficient of RAC is attributed to the fact that with the high water absorbing ratio of recycled aggregate，recycled aggregate concrete absorbs a certain amount of water in the process of mixing，and part of the water was gradually released in the hydration．The process increased concrete curing humidity，produced a kind of″internal curing″effect on RAC，made cement hydration full，and increased the compactness of recycled concrete，thus promoting the recycled aggregate concrete resistance to chloride ion diffusion［23］．Additionally，the result would suggest the importance of the early－age curing to improve the RAC resistance to chloride ion permeability．

2．2 Effect of curing age under different compressive stress ratios

The relationships between the chloride diffusion coefficient of NAC and RAC and curing age under compressive stresses are shown in Figs．5，6，respectively．With the increase of the curing age，the chloride diffusion coefficients of both NAC and RAC generally decrease，no matter how large compressive stress ratios are applied．This is due to the fact that with the growth of curing age，the degree of hydration of concrete increases and the internal micro cracks decrease continuously．Additionally，the chloride diffusion coefficients of NAC and RAC decrease fast at the beginning and then slow down with the increase ofcuring age．But the chloride diffusion coefficient of NAC decreases slowly after 28d，while the chloride diffusion coefficient of RAC decreases slowly after 90d．It is due to the internal curing effect of recycled aggregate concrete mentioned above，which promotes the improvement of the resistance to chloride ion penetration of RAC from 28dto 90d．

Fig．5 Curing age versus chloride diffusion coefficient of natural aggregate concrete under different compressive stress levelsλ

Fig．6 Curing age versus chloride diffusion coefficient of recycled aggregate concrete under different compressive stress levels

2．3 Relationship between curing age and chloride diffusion coefficient of recycled aggregate concrete under compressive stresses

According to the above analyses，the chloride diffusion coefficient of RAC has a good correlation with the curing age，which is consistent with the research results of NAC chloride diffusion coefficient obtained by Mangat et al．［4］and Hong et al．［5］．For RAC and NAC under different compressive stress ratios，the relationships between the chloride diffusion coefficientD／D0and curing aget／t0are nearly suitable to power functions．The fitting formulas and curves are shown in Table 6and Figs．7，8，respectively．

Table 6 The fitting formulas

Fig．7 D／D0versus t／t0for NAC

Fig．8 D／D0versus t／t0for RAC

For both NAC and RAC，the slope of the curve under the compressive stress ratio 0．3is gentler than that of the curves under the compressive stress ratio 0．0and 0．6，which indicates that the compressive stress ratio can change the level of involvement of the curing age on the concrete chloride diffusion coefficient．This might be related to the closure and expansion of micro cracks in concrete subjected to compressive stresses．Under smaller compressive stress ratio，the closure of micro cracks in concrete will lead to the lower influence of the curing age on the chloride diffusion coefficient．While under larger compressive stress ratio，as the micro cracks in concrete expands，the improvement of the curing age on the internal structure of the concrete become significant，which could lead to an obvious decrease in chloride diffusion coefficient as the curing age increases［11］．

Furthermore，to verify the validity of the fitting formulas of concrete in Table 6，the experimental results from Refs．［15－17］are compared with the calculated values ofD／D0based on the proposed fitting formulas．Table 7shows the validation results．

In Table 7，the calculated values concur with the experimental ones．Therefore，the empirical formulas of this study can express the relationships between chloride diffusion coefficient and age of concrete well．

Table 7 Validation results of the fitting formulas of concrete

3 Conclusions

The influence of curing age on chloride diffusion coefficient of recycled aggregate concrete under different compressive stress levels is investi－gated and the following conclusions can be drawn：

（1）With no stresses，the chloride diffusion coefficient of recycled aggregate concrete decreases with the increase of curing age and the rate of descent evidently presents″fast followed by slow″type，which is consistent with the result of natural aggregate concrete．Whereas compared with the natural aggregate concrete，the chloride diffusion coefficient of recycled aggregate concrete drops sharply in the earlier stage of curing．

（2）Under different compressive stress ratios，the chloride diffusion coefficient of recycled aggregate concrete generally decreases with the increase of curing age．And the internal curing effect of recycled aggregate concrete promotes the improvement of the resistance to chloride ion penetration of RAC from 28dto 90d．

（3）For both the recycled aggregate concrete and the natural aggregate concrete，the chloride diffusion coefficient approximately has a power function with the curing age and the relationship models are proposed under the compressive stress levels of 0，0．3，and 0．6，respectively and the performance of the relationship models was verified by the experimental data of other researchers．And the influence of curing age on chloride diffusion coefficient of concrete under higher compressive level is more remarkable than that under lower compressive level．

Acknowledgements

This work was supported by the Fundamental Research Funds for the Central Universities and Foundation of Graduate Innovation Center in Nanjing University of Aeronautics and Astronautics （No．kfjj20150105）and the National Natural Science Foundation of China（No．51279074）．

［1］ WU X Y，WEN D R．The unprecedented development of concrete industry in China ［J］．Concrete，2004，7：7－11．（in Chinese）

［2］ ZHUANG Xiao Jian．Recycled concrete［M］．Beijing：China Architecture and Building Press，2008，3．（in Chinese）

［3］ TANG L，NILSSON L O．Chloride diffusivity in high strength concrete at different ages ［J］．Nordic Concrete Research，1992，2：167－171．

［4］ MANGAT P S，MOLLOY B T．Prediction of long term chloride concentration in concrete ［J］．Mater Struct，1994，27（6）：338－346．

［5］ HONG L，DUO R M．Influence of curing age and water－binder ratio on chloride permeability under freeze－thaw and load［J］．Applied Mechanics and Materials，2013，405：2610－2615．

［6］ LIMBACHIYA M C，LEELAWAT T，DHIR R K．Use of recycled concrete aggregate in high－strength concrete［J］．Mater Struct，2000，33（10）：574－580．

［7］ ZHANG D，XU E，ZHOU X．Research on anti－penetration performance of recycled concrete ［J］．Concrete，2010，9：65－67．（in Chinese）

［8］ YE T，XU Y，ZHANG J．Experimental study on chloride penetration resistance performance of recycled concrete［J］．Journal of Changchun University of Technology，2014，5：567－571．（in Chinese）

［9］ WANG W，WU J，WANG Z，et al．Chloride diffusion coefficient of recycled aggregate concrete under compressive loading［J］．Mater Struct，2016，49：1－8．

［10］Chinese National Standard．Recycled coarse aggregate for concrete：GB／T 25177－2010［S］．Beijing：Standards of China，2010［S］．（in Chinese）

［11］LI H M，WU J，SONG Y J，et al．Effect of external loads on chloride diffusion coefficient of concrete with fly ash and blast furnace slag［J］．J Mater Civil Eng，2014，26（9）：04014053．

［12］ NORDTEST．Chloride migration coefficient from non－steady state migration experiment：NT BUILD 492－1999［S］．Espoo，F(xiàn)inland：［s．n．］，1999．

［13］JIANG L H，SONG Z J，YANG H，et al．Modeling the chloride concentration profile in migration test based on general Poisson Nernst Planck equations and pore structure hypothesis ［J］．Constr Build Mater，2013，40：596－603．

［14］ZHOU S，ZHOU J，ZHANG J．Experiment study on relationship between chloride diffusion in concrete and time［J］．Concrete，2011，4：46－47．（in Chinese）［15］OLORUNSOGO F T，PADAYACHEE N．Performance of recycled aggregate concrete monitored by durability indexes［J］．Cement and Concrete Research，2002（32）：179－185．

［16］VZQUEZ E，BARRA M，APONTE D，et al．Improvement of the durability of concrete with recycled aggregates in chloride exposed environment［J］．Constr Build Mater，2014，67：61－67．

［17］KIM K，SHIN M，CHA S．Combined effects of recycled aggregate and fly ash towards concrete sustainability［J］．Constr Build Mater，2013，48：499－507．

［18］SHI K，ZHOU X，ZHENG J．Effects of the curing time on the chloride diffusivity of concrete［J］．The World of Building Materials，2014，35（2）：23－26．（in Chinese）

［19］LI C，LI S W，ZHOU，Y．Changes law and correlation research on chloride diffusion coefficient of concrete by RCM ［J］．Construction Technology，2013，18：58－61．（in Chinese）

［20］ZHAO J，CAI G，GAO D，et al．Influences of freeze－thaw cycle and curing time on chloride ion penetration resistance of sulphoaluminate cement concrete［J］．Constr Build Mater，2014，53（2）：305－311．

［21］ZHOU D，ZHOU W，LIN W．Experimental study on durability of recycled aggregate concrete［J］．Journal of China and Foreign Highway，2011，31（1）：188－190．（in Chinese）

［22］WANG J，ZHAO K，WANG W．Experimental study on the effect of air content and curing age on the resistance to chloride ion penetration of concrete ［J］．Railway Quality Control，2009，37（2）：20－22．（in Chinese）

［23］LUO S，ZHENG X，HUANG H．Experimental study on pretreatment of recycled coarse aggregate and creep behavior of recycled aggregate concrete［J］．Journal of Building Materials，2016，19（2）：242－247．（in Chinese）