雙水相萃取技術的新發展

吳丁丁,穆小靜,易小琦,陳 剛

(重慶大學化學化工學院,重慶 401331)

雙水相萃取技術的新發展

吳丁丁,穆小靜*,易小琦,陳 剛

(重慶大學化學化工學院,重慶 401331)

雙水相萃取技術是一種易于放大、操作條件溫和、可連續化操作的新型分離技術。本文綜述了新近發展的不同的雙水相體系(聚合物-鹽-水、有機溶劑-鹽-水、離子液體-鹽-水、離子液體-表面活性劑-鹽-水)的性質,及萃取(提取)蛋白質、氨基酸、抗生素和中藥材中小分子有效成分等的影響因素;總結了雙水相萃取與其它技術的聯用,展望了雙水相體系的應用前景。

雙水相萃取,聚合物,有機溶劑,離子液體,聯用技術

雙水相體系(aqueous two-phase system,ATPS)由兩種互不相溶的水溶液組成,在萃取過程中,分子間氫鍵、鹽析作用、電荷相互作用、范德華力、聚合現象、疏水作用、界面性質作用等都扮演著十分重要的角色。這些作用力導致待萃取物在兩相間產生濃度差異,從而實現分離。雙水相萃取在提取中兼具分離功能,具有較高的生物相溶性、易于放大、可連續化操作、不易引起蛋白質的變性失活。該技術已經被應用于蛋白質、核酸、氨基酸、抗生素、色素以及中藥材中的小分子化合物等產品的分離和純化,必將在生物工程、食品、制藥等領域廣泛應用。

1956年Albertsson首次應用ATPS成功分離葉綠素[1]。目前對ATPS分離技術的研究方興未艾,新的體系層出不窮,應用領域不斷拓展。劉磊磊等[2]綜述了近5年來雙水相技術在中藥黃酮、生物堿、萜類、多酚及其它有效成分的分離中的應用。本文就近年來出現的新ATPS體系,闡述影響雙水相提取分離的因素如組成雙水相體系的聚合物、有機溶劑的種類、離子液體、表面活性劑的種類、鹽的種類及濃度、體系的pH等;并介紹了新發展的雙水相與其它技術的聯用。

1 雙水相體系的組成及應用

鹽是多數ATPS組成的重要成分之一,對ATPS萃取效果有顯著影響。要求鹽在水中有較大溶解度和解離度,價格低廉,常見的有:(NH4)2SO4、NaH2PO4、K2CO3、Na2SO4、K2HPO4、Na2CO3、CaCl2、KH2PO4、NaCl等。萃取酸性化合物時,選擇較低pH,一般用酸性鹽或中性鹽;反之,若萃取堿性化合物,一般選用堿性pH,用堿性或中性鹽,以保證被萃取的化合物以分子狀態存在,被萃取到上相。若被萃取對象以離子狀態存在,將加大其在鹽水相的分配。

鹽的濃度對分配系數和純化因子也有影響。B[mim]BF4離子液體與不同種類的鹽(NaH2PO4、K2HPO4、(NH4)2SO4、MgSO4)組成的ATPS提取小麥酯酶,發現NaH2PO4優于其它種類的鹽;并且隨著NaH2PO4質量分?jǐn)?shù)不斷增大,小麥酯酶在雙水相中的分配系數不斷增大。當鹽的質量分?jǐn)?shù)從15%增大至25%時,分配系數K由1.86±0.01增大到7.27±0.06,當鹽的質量分?jǐn)?shù)繼續增大,小麥酯酶在雙水相中的K緩慢增大至8.62±0.09,但是小麥酯酶的純化因子在NaH2PO4的質量分?jǐn)?shù)為25%時達到最大(4.23±0.04),NaH2PO4質量分?jǐn)?shù)增大至30%時,純化因子降低至1.97±0.04[13]。

在ATPS中加入兩種或兩種以上的鹽,能夠改變被萃取化合物在兩相中的分配,加快相分離的速度。如丙醇-K2HPO4/KH2PO4組成的ATPS中櫻桃蘆丁的K值為42.76;當加入2.5% NaCl時,K值提高到51.47[14]。丙醇-(NH4)2SO4ATPS在pH2.0時萃取分離蒜氨酸((S)-3-(烯丙基亞磺酰)-L-丙氨酸),加入8.54% NaCl后,K值從0.060減小至0.042,提取率增大[15]。蘆薈中的多糖和蛋白質在由(NH4)2SO4、NaH2PO4分別與B[mim]BF4離子液體組成的雙水相體系中的萃取率分別低于70%和90%,但向體系中加入1.33 mol/L NaCl,多糖和蛋白質在這兩種體系中的萃取率高于90%[16]。

可見,鹽對ATPS的性質以及萃取的結果有重要影響,但影響的原因尚待研究者們進一步從理論上深入解析。組成ATPS的其它組分對萃取的結果影響較大。

除了鹽以外,按照ATPS的其他組分對其進行分類,通常有以下幾類:聚合物-鹽-水[6,17]、有機溶劑-鹽-水[4,18]、離子液體-鹽-水[19]、離子液體-表面活性劑-水[20-21]、其他體系如聚合物1-聚合物2-水[22]等。

1.1 聚合物-鹽-水體系

由于聚合物黏度較大,相比于兩種聚合物形成的雙水相體系,聚合物-鹽體系得到更多的應用。而在聚合物-鹽體系中,聚乙二醇-鹽-水體系的應用最為廣泛。

1.1.1 聚乙二醇-鹽-水體系 PEG是平均分子量從200到20000的乙二醇高聚物的總稱。PEG的分子量對形成的ATPS性質有較大影響,構成PEG-鹽-水體系的雙水相所使用PEG分子量一般介于300～6000之間,但最常用的體系或萃取效率較好的雙水相體系使用的PEG分子量在1500～6000之間。PEG分子量太小,上相的極性太大;兩相的極性差異小,不利用分配系數的提高;若PEG分子量太大,其疏水性強,水中溶解度小,形成雙水相的PEG濃度降低,也不易于獲得較高的提取效率。不同分子量的PEG對雙水相的形成和性質有以下三個方面的差異:PEG及鹽在形成雙水相時所需的質量分?jǐn)?shù)。如在提取分離丁酸[10]和紅豆蛋白質[7]時,發現不同的PEG分子量對相圖有影響,當所選的鹽質量分?jǐn)?shù)一定時,隨著PEG相對分子質量的增大,憎水程度越強,加大了相分離的動力,因此形成雙水相體系所需PEG的濃度降低。PEG分子量對萃取率有影響。萃取丁酸[10]時,分子量為6000形成雙水相的萃取率達到最大。但當萃取對象為紅豆蛋白質[7]時,PEG6000形成的雙水相萃取率較低,可能是由于PEG相對分子質量高,疏水性較大,紅豆蛋白不易向上相分配。PEG分子量對分配系數有影響。從馬鈴薯中提取轉化酶[8]時發現隨著PEG分子量的增大,分配系數增大。當分子量超過4000,體積排阻效應變大,分配系數反而減小。因此,選擇PEG分子量的大小時需要綜合考慮上述幾個因素的影響。

聚乙二醇(PEG)-鹽-水體系含水量高[3,23]且兩相容易分離,蛋白質不易變性失活,因此研究者將這一體系用以提取生物活性的蛋白質。后來發現該體系可以用來提取小分子物質,如酚類化合物[3]、丁酸[10]、黃連生物堿[5]等能獲得較好的收率,成本低,污染小。

1.1.2 其他聚合物-鹽-水體系 除了聚乙二醇以外,質量分?jǐn)?shù)為50%氧化乙烯和質量分?jǐn)?shù)為50%氧化丙烯組成的共聚物EO50PO50構成的ATPS分離溶菌酶[24]。相對于PEG-鹽體系,該體系成本更低,適合工業化生產。

1.2 有機溶劑-鹽-水體系

與聚合物-鹽-水體系相比,有機溶劑組成的ATPS黏度小,溶劑和萃取物易回收。組成ATPS的有機溶劑一般與水可以混溶,有機溶劑的極性小,則其相應的ATPS體系的上相極性小;反之,有機溶劑的極性大則其相應的ATPS體系的上相極性大。這些體系一般不適合分離蛋白質、多肽,而用來提取分離小分子化合物。如:花青素[25]、白藜蘆醇[26]、辣椒素[27]、綠原酸[28]等化合物,提取時應選擇適合的pH。例如乙醇-NaH2PO4ATPS萃取和分離花青素時,pH>3.31花青素的回收率將會降低,pH>4.20 NaH2PO4將會沉淀。當萃取生物堿[29]等堿性化合物時,體系的pH調節在堿性范圍內。總之,pH的選擇依據是萃取的化合物在雙水相中能夠以分子狀態存在。

乙醇-(NH4)2SO4組成的ATPS中加入環糊精,色氨酸光學對映體在上相與下相中的分配系數有明顯差異,從而實現對映體的分離[23]。pH對ATPS萃取分離色氨酸對映體具有顯著影響,隨著pH增大,D-色氨酸與L-色氨酸在雙水相中的分配系數先增大后下降,在pH=3時,D-色氨酸與L-色氨酸的分配系數差異最大,色氨酸對映體的分離效果最好,分離系數(α=KD/KL)為1.38。該法為手性化合物的分離純化提供了一種便捷、新穎的方法。

丙醇-鹽-水、丙酮-鹽-水ATPS也是常用的萃取體系,如萃取蒽醌類化合物[30]、蒜氨酸[15]、鹽酸土霉素[31]、琥珀酸[32]等。

1.3 離子液體-鹽-水體系

離子液體(ionic liquid,IL)一般由有機陽離子和陰離子組成。常見的有機陽離子有咪唑鹽離子、季銨鹽離子、N-烷基吡啶離子等。陰離子分為有機陰離子和無機陰離子,常用的有鹵素離子、四氟硼酸根離子、六氟酸根離子、硝酸鹽及醋酸鹽等。離子液體蒸汽壓低、較高的熱化學穩定性。相對于由PEG組成的ATPS,離子液體的ATPS黏度低、不易乳化、相分離速度快。

IL-鹽-水體系常被用來分離大分子物質(如蛋白質、多肽、酶等)。例如有三個課題組采用IL-鹽-水體系來分離牛血清白蛋白(BSA)[33-35]。選用K2HPO4是因其溶解度大且具有提取BSA適宜的pH。在ATPS中IL的種類對萃取BSA的分配系數、提取效率等有較大影響。BSA在[bmim][Br]、[bmim][Cl]、[OH-mim][Cl]組成的ATPS中K值在1.97～3.04之間,而類膽汁離子液體組成的ATPS中BSA的分配系數達到7.68,提高了2～3倍[33]。Chen等[35]則比較了8種IL形成的ATPS對BSA萃取率的影響。這8種IL分別由兩種陽離子N,N-二甲基乙醇胺(DMEA)、二乙基乙醇胺(DEEA)和4種陰離子丙酸(Pr)、丁酸、戊酸、己酸構成。若IL的陽離子為DMEA,隨著陰離子鏈長增加,雙水相對BSA萃取率從99.47%下降到64.80%;若陽離子為DEEA,陰離子隨著鏈長增加萃取率則是從89.43%下降到58.70%。這表明IL的陽離子相同時,隨著陰離子烷基鏈的不斷增長,離子液體的疏水性增強,BSA的萃取率降低。當IL的陰離子相同時,烷基鏈長的陽離子,IL的水溶性低,溶液的黏度增加,體系對BSA的萃取率降低。因此[DMEA][Pr]是這8種離子液體中萃取BSA最佳的離子液體。由1,1,3,3-四甲基胍(1,1,3,3-tetramethylguandine,TMG)陽離子與8種不同的陰離子(醋酸鹽、山梨酸鹽、衣康酸鹽、丙烯酸鹽、甲基丙烯酸鹽、乳酸鹽、肉桂酸鹽、馬來酸鹽)組成的ATPS在萃取分離BSA時,TMG與丙烯酸鹽組成的離子液體(TMGA)對BSA的萃取率高,達99.46%[34]。

四種離子液體[C4mim][N(CN)2]、[C4mpyr]Cl、[C4mim]Cl和[C8mim]Cl分別與磷酸鹽緩沖液構成的ATPS提取脂肪分解酶[36],在pH=7.0時,脂肪酶(pI=3.0)帶負電荷,使得親水性增加,脂肪酶向鹽相轉移。[C4mim][N(CN)2]-磷酸緩沖液體系對脂肪酶的提取效果好,分配系數K=0.049±0.003。不僅如此,離子液體-鹽-水體系還能被用來分離小分子物質,如磺酰胺類化合物[37]、五倍子酸[38]等。

1.4 離子液體-表面活性劑-鹽-水體系

在離子液體-鹽-水體系中加入表面活性劑形成新型ATPS。當加入2.33%十二烷基苯磺酸鈉(SDBS)時,C6[mim]BF4和C8[mim]BF4與(NH4)2SO4溶液形成的ATPS遭破壞,而C4[mim]BF4-(NH4)2SO4-水體系中,SDBS加入使形成ATPS需要的IL量極少(0.1%),該體系可以提取糖果中的蘇丹紅Ⅰ-Ⅳ[39]。C4[mim]Cl-PEG300-Na2SO4雙水相體系提取沒食子酸、香草酸、丁香酸時,分配系數大于30.0,而在PEG300-Na2SO4中,三種化合物的分配系數低于20.0[40]。

1.5 其他體系

根據雙水相形成的基本原理,研究者以聚合物代替鹽,發展了聚合物-有機溶劑-水和聚合物-聚合物-水體系。右旋糖苷(Dx)-乙腈-水ATPS體系中右旋糖苷與水分子形成氫鍵,與有機溶劑競爭水而形成雙水相,右旋糖苷主要分布在下層,乙腈在上層,香草醛被提取到上層,分配系數K=11.30,萃取率達95%[41]。Wu等[42]從人體血清白蛋白中提取免疫球蛋白G時比較了四種ATPS對其回收率的影響,分別為聚合物-聚合物-水體系(PEG-HPS(羥丙基淀粉)-水、PEG-Dx-水體系)和聚合物-鹽-水體系(PEG-硫酸鹽-水、PEG-磷酸鹽-水),K<1;向體系中加入15% NaCl,免疫球蛋白G由原本向下相富集轉變?yōu)橄騊EG相富集,K>1,且在PEG-HPS-水體系中的回收率最高(高于90%)。以表面活性劑-木糖醇-水組成的ATPS從南瓜種子中提取和純化脂肪酶,這三種表面活性劑組成的ATPS對脂肪酶的純化因子大小順序:TritonX-100(PF>7.31)>Tween-80(PF<3.33)>SDS[43]。

2 雙水相萃取技術與其他技術的聯用

ATPS萃取方法相對于傳統的提取方法而言,不使用或少量使用有機溶劑,并且在適宜條件下選擇性較好。但該方法與傳統的液-液萃取技術一樣,從成分復雜的固體樣品中萃取目標組分受基質狀態、傳質的影響較大,相分離的時間長。與其他技術如微波輔助[29,44-45]、超聲波輔助[46-49]、溶劑浮選[50]等聯用能使ATPS的分離時間短、選擇性高,如表1。

表1 雙水相技術與其他技術的聯用Table 1 Aqueous two-phase extraction technique combined with other technologies

注:回收率指富集相中萃取物的質量與投入原料粗提液中目標物質的質量之比;萃取率指富集相中目標萃取物的質量與投入原料的質量之比。

微波輔助的ATPS比單一的微波萃取或熱回流提取的方法的萃取時間短,萃取率更高。例如:從苦參中分離生物堿[29],從降香黃檀葉中提取染料木黃酮和鷹嘴豆芽素A[44]以及從葡萄種子中分離酚醛樹脂[45]等。超聲波輔助的ATPS技術從花椒中分離木酯素[46],比傳統的熱回流法萃取率高,木脂素的純度高、選擇性好,萃取時間也大大縮短。雙水相浮選的方法從黃苓中分離黃苓苷[50],黃苓苷濃集系數大、以及所需的有機溶劑量少。

3 結論及展望

ATPS用于提取蛋白質等生物活性物質時,操作簡單,體系含水量高,在萃取過程中保持物質的構象穩定,蛋白不易失活并獲得高的萃取率。ATPS萃取方法用來從中藥材等固體基質中提取小分子化合物的起步較晚,它兼具固液萃取的功能和液-液萃取的分離的功能,通過選擇合適的pH、鹽、有機溶劑、聚合物、離子液體或表面活性劑的種類和濃度,使萃取有較強的選擇性和良好的提取效率。但是,構成ATPS體系的兩相極性均較強,所以該法僅適合于提取分離極性較強的組分。在中藥材提取中,由于多種有效成分極性跨度較大,因此該技術在多組分同時提取的應用中有較強局限性。未來,可以在雙水相技術的基礎上,構建三相體系或多相體系,從而實現多組分的高效同時提取和初步分離。這一技術因綠色環保將在生物工程、食品、中藥制藥、健康產品等領域有廣泛應用。

[1]Albertsson P A. Chromatography and partition of cells and cell fragments[J]. Nature,1956,177(4513):771-774.

[2]劉磊磊,李秀娜,趙帥. 雙水相萃取在中藥活性成分提取分離中的應用進展[J]. 中草藥,2015,46(5):766-773.

[3]Xavier L,Freire M S,Vidal-Tato I. Aqueous two-phase systems for the extraction of phenolic compounds from eucalyptus(Eucalyptusglobulus)wood industrial wastes[J]. Journal of Chemical Technology & Biotechnology,2014,89(11):1772-1778.

[4]Lakshmi M C,Madhusudhan M C,Raghavarao K S M S. Extraction and purification of lipoxygenase from soybean using aqueous two-phase system[J]. Food and Bioprocess Technology,2009,5(1):193-199.

[5]王鳳薇,王道武,郭青鋒,等. 雙水相萃取黃連生物堿[J]. 精細化工,2015(6):642-645.

[6]Pimentel M C B,Araujo A I,Figueiredo Z M B,et al. Aqueous two-phase system for citrinin extraction from fermentation broth[J]. Separation and Purification Technology,2013,110:158-163.

[7]孫亞莉,張喜峰. 雙水相萃取分離紅豆蛋白質[J]. 中國釀造,2013(6):114-118.

[8]Yuzugullu Y,Duman Y A. Aqueous two-phase(PEG4000/Na2SO4)extraction and characterization of an acid invertase from potato tuber(Solanumtuberosum)[J]. Preparative Biochemistry & Biotechnology,2015,45(7):696-711.

[9]Da Silva R M M,Coimbra J S D R,Da Silva C A,et al. Green extraction by aqueous two-phase systems of porcine pancreatic and snake venom phospholipase A2[J]. Separation and Purification Technology,2015,141:25-30.

[10]Wu X T,Li G X,Yang H L,et al. Study on extraction and separation of butyric acid from clostridium tyrobutyricum fermentation broth in PEG/Na2SO4aqueous two-phase system[J]. Fluid Phase Equilibria,2015,403:36-42.

[11]鄭曉杰,葉興乾,吳祥庭. 苦苣皂甙的PEG/MgSO4雙水相萃取優化及其抗氧化評價[J]. 中國食品學報,2015(6):110-116.

[12]Yang X,Zhang S,Yu W,et al. Ionic liquid-anionic surfactant based aqueous two-phase extraction for determination of antibiotics in honey by high-performance liquid chromatography[J]. Talanta,2014,124:1-6.

[13]Jiang B,Feng Z B,Liu C H,et al. J. Extraction and purification of wheat-esterase using aqueous two-phase systems of ionic liquid and salt[J]. Journal of Food Science and Technology,2015,52(5):2878-2885.

[14]Reis I A O,Santos S B,Pereira F D S,et al. Extraction and recovery of rutin from acerola waste using alcohol-salt-based aqueous two-phase systems[J]. Separation Science and Technology,2014,49(5):656-663.

[15]Jiang X M,Lu Y M,Tan C P,et al. Combination of aqueous two-phase extraction and cation-exchange chromatography:new strategies for separation and purification of alliin from garlic powder[J]. Journal of Chromatography B,Analytical Technologies in the Biomedical and Life Sciences,2014,957:60-67.

[16]Tan Z J,Li F F,Xu X L,et al. Simultaneous extraction and purification of aloe polysaccharides and proteins using ionic liquid based aqueous two-phase system coupled with dialysis membrane[J]. Desalination,2012,286:389-393.

[17]Reschke T,Brandenbusch C,Sadowski G. Modeling aqueous two-phase systems:II. Inorganic salts and polyether homo-and copolymers as ATPS former[J]. Fluid Phase Equilibria,2014,375:306-315.

[18]Reis I A O,Santos S B,Santos L A,et al. Increased significance of food wastes:Selective recovery of added-value compounds[J]. Food Chemistry,2012,135(4):2453-2461.

[19]Berton P,Monasterio R P,Wuilloud R G. Selective extraction and determination of vitamin B-12 in urine by ionic liquid-based aqueous two-phase system prior to high-performance liquid chromatography[J]. Talanta,2012,97:521-526.

[20]Wang Y,Han J,Liu J,et al. Liquid-liquid equilibrium phase behavior of iminazolium-based ionic liquid aqueous two-phase systems composed of 1-alkyl-3-methyl imidazolium tetrafluoroborate and different electrolytes ZnSO4,MgSO4and Li2SO4at 298.15 K:Experimental and correlation[J]. Thermochimica Acta,2013,557:68-76.

[21]Wang X H,Wei X L,Liu J,et al. Study on the aqueous two-phase systems composed of surfactant,ionic liquid and water[J]. Fluid Phase Equilibria,2013,347:1-7.

[22]Sarubbo L A,Oliveira L A,Porto A L F,et al. New aqueous two-phase system based on cashew-nut tree gum and poly(ethylene glycol)[J]. Journal of Chromatography B-Analytical Technologies in the Biomedical and Life Sciences,2000,743(1-2):79-84.

[23]Chen X Q,Dong Q L,Yu J G,et al. Extraction of Tryptophan enantiomers by aqueous two-phase systems of ethanol and(NH4)2SO4[J]. Journal of Chemical Technology & Biotechnology,2013,88(8):1545-1550.

[24]Dembczynski R,Bialas W,Jankowski T. Recycling of phase components during lysozyme extraction from hen egg white in the EO50PO50/K2HPO4aqueous two-phase system[J]. Biochemical Engineering Journal,2010,51(1-2):24-31.

[25]Wu Y C,Wang Y,Zhang W L,et al. Extraction and preliminary purification of anthocyanins from grape juice in aqueous two-phase system[J]. Separation and Purification Technology,2014,124:170-178.

[26]He Y Z,Wang B,Zhuang Y,et al. Study on separation and purification of resveratrol in wine grape residue with aqueous two phase extraction method[J]. Advanced Materials Research,2012,550-553:1743-1746.

[27]Zhao P P,Lu Y M,Tan C P,et al. Aqueous two-phase extraction combined with chromatography:new strategies for preparative separation and purification of capsaicin from capsicum oleoresin[J]. Applied Biochemistry and Biotechnology,2015,175(2):1018-1034.

[28]Tan Z J,Wang C Y,Yi Y J,et al. Extraction and purification of chlorogenic acid from ramie(BoehmerianiveaL. Gaud)leaf using an ethanol/salt aqueous two-phase system[J]. Separation and Purification Technology,2014,132:396-400.

[29]Zhang W,Zhu D,Fan H J,et al. Simultaneous extraction and purification of alkaloids from Sophora flavescens Ait. by microwave-assisted aqueous two-phase extraction with ethanol/ammonia sulfate system[J]. Separation and Purification Technology,2015,141:113-123.

[30]Tan Z J,Li F F,Xu X L. Extraction and purification of anthraquinones derivatives from Aloe vera L. using alcohol/salt aqueous two-phase system[J]. Bioprocess and Biosystems Engineering,2013,36(8):1105-1113.

[31]Han J,Hu S P,Wang Y. Extraction of oxytetracycline hydrochloride in aqueous two-phase system of acetone and ammonium sulfate[J]. Journal of the Chemical Society of Pakistan,2013,35(1):11-16.

[32]Gu B H,Zheng P,Yan Q,et al. Aqueous two-phase system:An alternative process for recovery of succinic acid from fermentation broth[J]. Separation and Purification Technology,2014,138:47-54.

[33]Huang S Y,Wang Y Z,Zhou Y G,et al. Choline-like ionic liquid-based aqueous two-phase extraction of selected proteins[J]. Analytical Methods,2013,5(13):3395.

[34]Zeng Q,Wang Y Z,Li N,et al. Extraction of proteins with ionic liquid aqueous two-phase system based on guanidine ionic liquid[J]. Talanta,2013,116:409-416.

[35]Chen J,Wang Y Z,Zeng Q,et al. Partition of proteins with extraction in aqueous two-phase system by hydroxyl ammonium-based ionic liquid[J]. Analytical Methods,2014,6(12):4067.

[36]Ventura S P M,De Barros R L F,De Pinho Barbosa J M,et al. Production and purification of an extracellular lipolytic enzyme using ionic liquid-based aqueous two-phase systems[J]. Green Chemistry,2012,14(3):734.

[37]Shao M Y,Zhang X L,Li N,et al. Ionic liquid-based aqueous two-phase system extraction of sulfonamides in milk[J]. Journal of Chromatography B,Analytical Technologies in the Biomedical and Life Sciences,2014,961:5-12.

[38]Cláudio A F M,Ferreira A M,Freire C S R,et al. Optimization of the gallic acid extraction using ionic-liquid-based aqueous two-phase systems[J]. Separation and Purification Technology,2012,97:142-149.

[39]Yu W,Liu Z L,Li Q,et al. Determination of Sudan I-IV in candy using ionic liquid/anionic surfactant aqueous two-phase extraction coupled with high-performance liquid chromatography[J]. Food Chemistry,2015,173:815-820.

[40]Almeida M R,Passos H,Pereira M M,et al. Ionic liquids as additives to enhance the extraction of antioxidants in aqueous two-phase systems[J]. Separation and Purification Technology,2014,128:1-10.

[41]De Brito Cardoso G,Souza I N,Pereira M M,et al. Aqueous two-phase systems formed by biocompatible and biodegradable polysaccharides and acetonitrile[J]. Separation and Purification Technology,2014,136:74-80.

[42]Wu Q,Lin D Q,Yao S J. Evaluation of poly(ethylene glycol)/hydroxypropyl starch aqueous two-phase system for immunoglobulin G extraction[J]. Journal of Chromatography B,Analytical Technologies in the Biomedical and Life Sciences,2013,928:106-112.

[43]Amid M,Manap M Y,Hussin M,et al. A novel aqueous two phase system composed of surfactant and xylitol for the purification of lipase from pumpkin(cucurbita moschata)seeds and recycling of phase components[J]. Molecules,2015,20(6):11184-11201.

[44]Ma F Y,Gu C B,Li C Y,et al. Microwave-assisted aqueous two-phase extraction of isoflavonoids from Dalbergia odorifera T. Chen leaves[J]. Separation and Purification Technology,2013,115:136-144.

[45]Dang Y Y,Zhang H,Xiu Z L. Microwave-assisted aqueous two-phase extraction of phenolics from grape(Vitisvinifera)seed[J]. Journal of Chemical Technology & Biotechnology,2014,89(10):1576-1581.

[46]Guo T,Su D,Huang Y,et al. Ultrasound-assisted aqueous two-phase system for extraction and enrichment of zanthoxylum armatum lignans[J]. Molecules,2015,20(8):15273-15286.

[47]馬藝丹,劉紅,廖小偉,等. 神秘果種子多酚超聲雙水相復合提取工藝及其抗氧化活性[J]. 食品與機械,2015(6):173-178.

[48]陳鋼,李棟林,史建鑫,等. 響應面實驗優化超聲耦合雙水相體系提取茶多酚工藝[J]. 食品科學,2016(6):95-100.

[49]李妍,李鋒,劉朝兵,等. 雙水相輔助超聲提取茄肉總黃酮及抗氧化性[J]. 應用化工,2016(1):107-110.

[50]Bi P Y,Chang L,Mu Y L,et al. Separation and concentration of baicalin from Scutellaria Baicalensis Georgi extract by aqueous two-phase flotation[J]. Separation and Purification Technology,2013,116:454-457.

Progress of aqueous two-phase extraction technique

WU Ding-ding,MU Xiao-jing*,YI Xiao-qi,CHEN Gang

(College of Chemistry and Chemical Engineering of Chongqing University,Chongqing 401331,China)

Extraction with aqueous two-phase system(ATPS)is a novel separation technique,which shows some advantages including easy scale-up,mild conditions and continuous operation. The properties and applications of newly developed different ATPSs(polymer-salt-water,organic solvent-salt-water,ionic liquid-salt-water,ionic liquid-surfactant-salt-water)in extraction of proteins,amino acids,antibiotics and other small molecules in herbs were reviewed. ATPS extraction combining with other technologies were summarized,and the prospect of ATPSs was also discussed.

aqueous two-phase extraction;polymer;organic solvent;ionic liquid;hyphenated technique

2016-08-12

吳丁丁(1990-)，女，碩士研究生，研究方向：分析化學，E-mail：18883724367@163.com。

*通訊作者:穆小靜(1973-)，女，博士，副教授，研究方向：藥物分析，E-mail:muxiaojingcn@aliyun.com。

重慶市重點產業共性關鍵技術創新專項(cstc2016zdcy-ztzx10001);重慶市科技支撐示范工程(cstc2014zktjccxyyBX0025)。

TS201.2

A

1002-0306(2017)08-0395-06

10.13386/j.issn1002-0306.2017.08.068