鄂爾多斯盆地大牛地氣田盒1段儲層應力敏感性及對水平井開發的影響

陳　奎，任廣磊，楊文娟，于耀南

(中國石化 華北油氣分公司 勘探開發研究院，河南 鄭州 450006)

?

鄂爾多斯盆地大牛地氣田盒1段儲層應力敏感性及對水平井開發的影響

陳奎，任廣磊，楊文娟，于耀南

(中國石化 華北油氣分公司 勘探開發研究院，河南 鄭州 450006)

大牛地氣田二疊系下石盒子組1段(盒1段)是典型的低滲透儲層。為明確儲層的應力敏感性，選取了不同類型的13塊巖心開展了應力敏感性實驗。結果表明，盒1段巖心普遍存在應力敏感，且存在滲透率滯后現象，這說明隨凈應力的增加，巖樣發生了塑性變形。采用內應力敏感指數法對實驗數據進行分析，結果表明物性較好的Ⅰ類儲層應力敏感性較弱，Ⅱ類、Ⅲ類儲層為弱～中等，13塊巖心的平均內應力敏感指數為0.086，整體評價應力敏感性為弱。建立了Ⅰ-Ⅲ類儲層的多級壓裂水平井數值模擬模型，并將儲層無因次滲透率隨地層壓力的變化關系加入到模型中。在定氣井產量的條件下，對比應力敏感對水平井開發的影響。數值模擬結果表明：對于Ⅰ類儲層，應力敏感對穩產時間和穩產期產氣量影響很小，僅降低1.6%；Ⅱ類儲層影響較小，降低了11.2%；Ⅲ類儲層則影響較大，降低了23.6%。因此應加強Ⅱ類、Ⅲ類儲層氣井的配產研究和生產管理，保證開發效果。

應力敏感；低滲透；水平井；氣田開發；大牛地氣田；鄂爾多斯盆地

大牛地氣田位于鄂爾多斯盆地伊陜斜坡北部東段，屬于典型的大型低滲致密砂巖氣田[1-4]。經過多年持續的產能建設，剩余未動用儲量主要位于二疊系下石盒子組1段(盒1段)，儲層物性差、豐度低，直井開發無效益，適宜采用水平井開發。而一般認為低滲透儲層比中高滲儲層存在更強的應力敏感性[5-7]。國內外針對儲層應力敏感的研究，主要集中在實驗測試方法上。應力敏感應用研究方面，主要是在滲流模型加入應力敏感因素，評價對油氣井產能的影響。對于具體區塊的研究，沒有針對不同類型儲層進行細分。而對于應力敏感對于氣藏多級壓裂水平井開發指標的研究也比較少[8-17]。有鑒于此，本文在大牛地氣田儲層分類評價研究成果的基礎上[18-19]，選取盒1段不同類型儲層巖心開展實驗，并將外應力敏感曲線通過有效應力將其轉換成內應力敏感曲線之后，評價儲層的應力敏感性。再將實驗結果導入氣藏多級壓裂水平井數值模擬模型，利用數值模擬研究應力敏感對開發指標的影響，為盒1段的開發提供指導。

1　應力敏感實驗

1.1實驗結果

實驗參照SY/T 6385—1999設計，以氮氣為氣體介質，根據大牛地氣田儲層分類評價標準[18-19]，選取了分別代表了盒1段Ⅰ類、Ⅱ類和Ⅲ類儲層的13塊巖心進行應力敏感性實驗。結果表明盒1段巖心普遍存在應力敏感。典型實驗結果如圖1和圖2所示，在凈應力增加過程中，滲透率隨凈應力的增加而減小，初期下降很快，當達到一定值后，下降幅度逐漸減小，趨于變緩。凈應力降低過程中，滲透率逐漸恢復，但是并不能恢復到原來的大小，且凈應力增加過程中的滲透率都大于對應的凈應力降低過程中的滲透率值，這是滲透率滯后現象。滲透率滯后現象說明隨凈應力的增加，巖樣發生了塑性變形。

圖1　大牛地氣田盒1段Ⅰ類巖樣D28-6滲透率與 凈應力關系Fig.1　Permeability vs. net stress of Type Ⅰ core sample(D28-6) of the 1st Member of Xiashihezi Formation in Daniudi gas field

圖2　大牛地氣田盒1段Ⅲ類巖樣D41-37滲透率與凈應力關系Fig.2　Permeability vs. net stress of type III core sample(D41-37) of the 1st Member of Xiashihezi Formation in Daniudi gas field

1.2滲透率應力敏感性評價與分析

目前常用的滲透率應力敏感性評價方法主要有行業標準法、應力敏感性系數法和應力敏感指數法。前兩種方法實際上評價的是巖石滲透率對外應力(圍壓)的敏感程度，而實際的油氣生產過程是內壓不斷改變的過程，所以油氣藏應力敏感性評價應采用內應力敏感指數法。

應力敏感指數的表達式為：

(1)

式中：SI為應力敏感指數，無因次；ki為原始地層壓力下的滲透率，10-3μm2；k為某個地層壓力下的滲透率，10-3μm2。

本文在用常規應力敏感實驗數據評價儲層巖石的內應力敏感性時，首先分別通過李傳亮的本體有效應力方法計算出的有效應力，將外應力敏感曲線轉換成內應力敏感曲線，然后才進行內應力敏感性評價[20-22]。根據常規實驗得到滲透率與凈應力成乘冪關系，可統一表示為：

(2)

用本體有效應力法得到的有效應力將外應力敏感曲線轉換成內應力敏感曲線后，上式即可寫成：

(3)

式中：k0為初始測點對應的滲透率，10-3μm2；σ為有效應力，MPa；b為巖石的應力敏感常數，MPa-1；pc為凈圍壓，MPa；pp為進口壓力值，MPa；Φ為孔隙度，%。

為了方便對比，將原始地層壓力降低10MPa時的孔隙壓力和圍壓代入轉換后的內應力敏感曲線關系，得到相應條件的滲透率值，然后根據式(1)計算出內應力敏感指數(表1)。結果表明，物性較好的Ⅰ類儲層應力敏感性為弱，Ⅱ類儲層應力敏感性為中等偏弱，物性差的Ⅲ類儲層應力敏感性大部分為中等。說明儲層越好，應力敏感性越弱。

表1　大牛地氣田盒1段巖樣內應力敏感指數Table 1　Internal stress sensitivity index of core samples of the 1st Member of Xiashihezi Formation in Daniudi gas field

2　應力敏感對水平井開發的影響

根據應力敏感實驗結果，結合儲層實際上覆巖層壓力以及實際地層流體壓力，將實驗曲線轉換到地下儲層滲透率隨地層流體壓力的變化關系。氣藏Ⅰ類、Ⅱ類和Ⅲ類儲層無因次滲透率隨地層壓力的變化關系見表2。

根據儲層分類，建立不同類型儲層的典型數值模擬模型，將表2數據加入模型，進行應力敏感數值模擬動態預測并對比分析，儲層參數取值見表3。水平井及分段壓裂參數為：水平段長度為1 100 m，采用局部加密網格模擬壓裂縫，壓裂段數11段，壓裂有效半縫長25 m，裂縫導流能力30×10-3μm2·m。

表2　大牛地氣田盒1段不同類型儲層無因次 滲透率隨地層壓力變化關系Table 2　Dimensionless permeability vs. formation pressure of different reservoir types of the 1st Member of Xiashihezi Formation in Daniudi gas field

表3　大牛地氣田盒1段水平井單井數值模擬儲層參數Table 3　Reservoir parameters for horizontal well numerical simulation of the 1st Member of Xiashihezi Formation in Daniudi gas field

為了便于對比，氣井生產制度統一設定為2.2×104m3/d。計算結果表明，Ⅰ類儲層不考慮應力敏感可穩產6.22年，而考慮應力敏感后穩產時間降低到6.12年，降低0.1年，降低幅度只有1.6%，應力敏感對開發的影響很小。Ⅱ類儲層不考慮應力敏感可穩產3.39年，而考慮應力敏感后穩產時間降低到3.01年，降低0.38年，降低幅度11.2%，應力敏感對開發的影響也比較小。Ⅲ類儲層不考慮應力敏感可穩產0.89年，而考慮應力敏感后穩產時間降低到0.68年，降低0.21年，降低幅度23.6%，應力敏感對開發的影響較大，如表4、圖3、圖4和圖5。因此Ⅲ類儲層氣井的產量不宜過高，以免較大的應力敏感影響穩產期累產氣量。

表4　大牛地氣田盒1段應力敏感對不同類型儲層影響Table 4　Influences of stress sensitivity on different reservoir types of the 1st Member of Xiashihezi Formation in Daniudi gas field

圖3　大牛地氣田盒1段應力敏感對Ⅰ類儲層影響Fig.3　Influences of stress sensitivity on type Ⅰ reservoirs of the 1st Member of Xiashihezi Formation in Daniudi gas field

圖4　大牛地氣田盒1段應力敏感對Ⅱ類儲層影響Fig.4　Influences of stress sensitivity on type Ⅱ reservoirs of the 1st Member of Xiashihezi Formation in Daniudi gas field

圖5　大牛地氣田盒1段應力敏感對Ⅲ類儲層影響Fig.5　Influences of stress sensitivity on type Ⅲ reservoirs of the 1st Member of Xiashihezi Formation in Daniudi gas field

3　結論

1) 實驗結果表明盒1段巖心普遍存在應力敏感。物性較好的Ⅰ類儲層，應力敏感性為弱，Ⅱ類儲層應力敏感性為中等偏弱，物性差的Ⅲ類儲層應力敏感性大部分為中等。

2) 考慮了應力敏感的水平井開發數值模擬結果表明，Ⅰ類儲層應力敏感對穩產期等指標的影響很小，Ⅱ類儲層影響較小，Ⅲ類儲層影響較大。

3) 盒1段Ⅲ類儲層氣井配產不宜過高，避免因應力敏感效應，對氣井穩產期及累產氣量產生較大影響。

[1]郝蜀民,惠寬洋,李良.鄂爾多斯盆地大牛地大型低滲氣田成藏特征及其勘探開發技術[J].石油與天然氣地質,2006，27(6)：762-768.

Hao Shumin,Hui Kuanyang,Li Liang.Reservoiring features of Daniudi low-permeability gas field in Ordos basin and its exploration and development technologies[J].Oil & Gas Geology,2006，27(6)：762-768.

[2]曲希玉，陳修，邱隆偉，等.石英溶解型次生孔隙的成因及其對儲層的影響——以大牛地氣田上古生界致密砂巖儲層為例[J].石油與天然氣地質，2015,36(5):804-813.

Qu Xiyu,Chen Xiu,Qiu Longwei,et al.Genesis of secondary pore of quartz dissolution type and its influences on reservoir:Taking the tight sandstone reservoir in the Upper Paleozoic of Daniudi gas field as an example[J].Oil & Gas Geology,2015,36(5):804-813.

[3]佘剛，周小鷹，戴明剛，等.波形分類技術在鄂北薄砂巖儲層預測中的應用[J].石油天然氣與地質，2012，33(4)：536-540.

She Gang,Zhou Xiaoying,Dai Mingang,et al.Application of seismic waveform classification technique in thin sandstones reservoir prediction in northern Ordos Basin[J].Oil & Gas Geology,2012，33(4)：536-540.

[4]楊辰雨，田景春，張翔，等.基于砂體構型精細刻畫潮坪砂壩優質砂體——以大牛地氣田D17井區太原組2段為例[J].石油與天然氣地質，2015，36(2):248-254.

Yang Chenyu,Tian Jingchun,Zhang Xiang,et al.Configuration-based fine description of high-quality sand bodies in tidal-flat bar—Taking the tight sandstone reservoir in the 2ndmember of the Taiyuan Formation in D-17 wellblock in Daniudi gasfield as an example[J].Oil & Gas Geology，2015，36(2)：248-254.

[5]羅瑞蘭.“對低滲儲層不存在強應力敏感”觀點的質疑[J].石油鉆采工藝，2006，28(2)：78-80.

Luo Ruilan.Queries to the viewpoint low permeability reservoirs have not the characteristics of strong stress sensitivity[J].Oil Drilling & Production Technology，2006，28(2)：78-80.

[6]羅瑞蘭.關于低滲致密儲層巖石的應力敏感問題—與李傳亮教授探討[J].石油鉆采工藝，2010，32(2)：126-130.

Luo Ruilan.Discussion of stress sensitivity of low permeability and tight reservoir rocks[J].Oil Drilling & Production Technology，2010，32(2)：126-130.

[7]劉曉旭,胡勇,朱斌,等.儲層應力敏感性影響因素研究[J].特種油氣藏,2006,13(3):18-21.

Liu Xiaoxu,Hu Yong,Zhu Bin,et al.Influential factor analysis of reservoir stress sensitivity[J].Special Oil and Gas Reservoirs,2006,13(3):18-21.

[8]張睿,寧正福,楊峰,等.頁巖應力敏感實驗與機理[J].石油學報,2015,36(2):224-231,237.

Zhang Rui,Ning Zhengfu,Yang Feng,et al.Shale stress sensitivity experiment and mechanism[J].Acta Petrolei Sinica,2015,36(2):224-231,237.

[9]高濤.特低滲砂巖油藏水平縫應力敏感實驗研究及產能計算[D].成都：西南石油大學,2015.

Gao Tao.Experimental study on stress sensitivity and productivity calculation of horizontal seam in extra low permeability sandstone reservoir[D].Chengdu：Southwest Petroleum University,2015.

[10]肖香姣,畢研鵬,王小培,等.一種新的考慮應力敏感影響的三項式產能方程[J].天然氣地球科學,2014,25(5):767-770.

Xiao Xiangjiao,Bi Yanpeng,Wang Xiaopei,et al.A new trinomial deliverability equation with consideration of stress sensitivity[J].Natural Gas Geoscience，2014,25(5):767-770.

[11]李傳亮,朱蘇陽.關于應力敏感測試方法的認識誤區[J].巖性油氣藏,2015,27(6):1-4.

Li Chuanliang,Zhu Suyang.Misunderstanding of measuring methods of stress sensibility[J].Lithologic Reservoirs，2015,27(6):1-4.

[12]李明軍,馬勇新,李紅東,等.海上異常高壓低滲透氣藏應力敏感實驗研究[J].鉆采工藝,2014,37(1):88-90.

Li Mingjun,Ma Yongxin,Li Hongdong,et al.Stress sensitivity experiment of offshore abnormal high pressure low permeability gas reservoir[J].Drilling & Production Technology,2014,37(1):88-90.

[13]竇晶晶,修乃嶺,嚴玉忠,等.基于應力敏感常數的致密砂巖儲層應力敏感性評價研究[J].重慶科技學院學報( 自然科學版),2015,17(4):10-13.

Dou Jingjing,Xiu Nailing,Yan Yuzhong,et al.Research on tight sandstone stress sensitivity reservoir based evaluation experiments of on stress sensitivity constant[J].Journal of Chongqing University of Science and Technology(Natural Science Edition),2015,17(4):10-13.

[14]何江,付永雷,沈桂川,等.低滲砂巖儲層巖石學特征與應力敏感性耦合關系——以鄂爾多斯盆地蘇里格-吉爾地區下石盒子組八段下亞段為例[J].石油與天然氣地質，2012,33(6):923-931.

He Jiang,Fu Yonglei,Shen Guichuan,et al.Coupling relations between the petrologic characteristics and stress-sensitiveness in low-permeability sandstone reservoirs:an example from the lower 8thmember of the Lower Shihezi Formation in Sulige-Jier area，Ordos Basin[J].Oil & Gas Geology,2012,33(6):923-931.

[15]劉峰,王裕亮,陳小凡,等.考慮應力敏感性的低滲透油藏油井產能分析[J].石油與天然氣地質，2013,34(1):124-128.

Liu Feng,Wang Yuliang,Chen Xiaofan,et al.Analysis on oil well productivity of low-permeability reservoirs with stress-sensitivity being taken into considerations[J].Oil & Gas Geology,2013,34(1):124-128.

[16]楊松，劉培亮，何昶，等.塔河油田底水砂巖油藏水平井剩余油主控因素分析[J].石油實驗地質，2015，37(S1): 23-28.

Yang Song，Liu Peiliang，He Chang，et al.Main controlling factors for remaining oils in horizontal wells in sandstone reservoirs with bottom water in the Tahe Oil Field.Petroleum[J].Geology & Experiment，2015，37(S1):23-28.

[17]雷剛,王昊,董平川,等.非均質致密砂巖應力敏感性的定量表征[J].油氣地質與采收率,2015,22(3):90-94

Lei Gang，Wang Hao，Dong Pingchuan，et al.Quantitative analysis on stress sensitivity of heterogeneous tight sandstone[J].Petroleum Geology and Revovery Efficiency，2015,22(3):90-94.

[18]侯瑞云,劉忠群.鄂爾多斯盆地大牛地氣田致密低滲儲層評價與開發對策[J].石油天然氣與地質,2012,33(1):118-128.

Hou Ruiyun,Liu Zhongqun.Reservoir evaluation and development strategies of Daniudi tight sand gas field in the Ordos Basin[J].Oil&Gas Geology,2012,33(1):118-128.

[19]郝蜀民,劉忠群,周涌沂,等.大牛地致密低滲氣田水平井整體開發技術[M].北京:石油工業出版社，2015：113-114.

Hao Shumin,Liu Zhongqun,Zhou Yongyi,et al.Integrated development technology of horizontal well in Daniudi tight and low permeability gas field[M].Beijing:Petroleum Industry Press，2015：113-114.

[20]李傳亮,孔祥言,徐獻芝,等.多孔介質的雙重有效應力[J].自然雜志,1999,21(5):288-292.

Li Chuanliang,Kong Xiangyan,Xu Xianzhi,et al.Double effective stress of porous media[J].Chinese Journal of Nature,1999,21(5):288-292.

[21]李閩,喬國安,陳昊．低滲砂巖儲層巖石應力敏感實驗與理論研究[J].鉆采工藝, 2006，29(4)：91-93.

Li Min,Qiao Guoan,Chen Hao.Experimental and theoretical study on rock stress-sensitivities in low permeability sandstone[J].Drilling & Production Technology,2006，29(4)：91-93.

[22]李傳亮.巖石應力敏感指數與壓縮系數之間的關系式[J].巖性油氣藏，2007，19(4)：95-98.Li Chuanliang.A theoretical formula of stress sensitivity index with compressibility of rock[J].Lithologic Reservoirs，2007，19(4)：95-98.

[23]李傳亮.儲層巖石的應力敏感性評價方法[J].大慶石油地質與開發,2006，25(1)：40-42.

Li Chuanliang.Evaluation method for stress sensitivity of reservoir rock[J].Petroleum Geology & Oilfield Development in Daqing,2006，25(1)：40-42.

(編輯張亞雄)

Stress sensitivity of the 1stMember of Xiashihezi Formation and its influences on horizontal well development of Daniudi gas field,Ordos Basin

Chen Kui,Ren Guanglei,Yang Wenjuan,Yu Yaonan

(ExplorationandDevelopmentResearchInstitute,SINOPECNorthChinaCompany,Zhengzhou,Henan450006,China)

The 1stMember of Xiashihezi Formation(H1)of Daniudi gas field is a typical low permeability reservoir in Ordos Basin.In order to clearly understand the stress sensitivity of H1,13 core samples of different types were chosen for stress sensitivity tests.The experimental results show that the core samples from H1 commonly show stress sensitivity and permeability hysteresis,indicating that the cores experience plastic deformation with the increasing of net stress.Analysis of the experimental data with internal stress sensitivity index method shows that the type Ⅰ reservoirs with better physical properties has a relatively low stress sensitivity,while the type Ⅱ and Ⅲ reservoirs have low to moderate stress sensitivity.The averaged internal stress sensitivity index of these 13 core samples is 0.086,indicating that the overall stress sensitivity is low.We built numerical simulation models of multi-stage fracturing of horizontal wells for Ⅰ-Ⅲ type reservoirs,into which the relationship between dimensionless permeability and the formation pressure was incorporated.Under a constant gas production rate scheme in the numerical model,the effects of stress sensitivity on horizontal well performance were investigated.The numerical simulation results show that the stress sensitivity has very little effect on gas rate during stable production period for type Ⅰ reservoir,which only decreased by 1.6% in comparison with that without stress sensitivity case.For type Ⅱ and Ⅲ reservoirs,the gas rate during stable production period decreased by 11.2% and 23.6%,respectively.Therefore,production allocation and management should be strengthened for type Ⅱ and Ⅲ reservoirs to guarantee well performance.

stress sensitivity,low permeability,horizontal well,gas field development,Daniudi gas field,Ordos Basin

2015-12-20;

2016-02-24。

陳奎(1980—)，男,碩士，工程師，氣藏工程。E-mail:1235199@qq.com。

國家科技重大專項(2011ZX05045)。

0253-9985(2016)02-0267-05

10.11743/ogg20160216

TE37

A